Preserving Garden Jewels - Homemade Tomato Juice

By Kathleen Guagliano (Katg) on June 16, 2010

Whether you have an overabundance of fresh garden tomatoes, go to a U-pick farm or purchase from a reliable vegetable vendor, this is a wonderful way to get the highest yield when preserving tomatoes.

Homemade Tomato Juice

It’s the end of Tomato season here in Florida but for many of you the season is just beginning. When all those tomatoes finally ripen, you may be wondering what to do with them. Whether you go to a U-pick farm, purchase from a reliable vegetable vendor or have an overabundance of fresh garden tomatoes, this is a wonderful way to get the highest yield for your efforts. It's a great project for a rainy afternoon as it's a little time consuming and on the messy side, but is so worth the results. There's no artificial preservatives and you can season it the way you like. 

I used 30lbs of tomatoes and I managed to make 10 quarts of juice. This is great juice for drinking or it can also be used for cooking. In this recipe I didn’t spice it up too much…I just added a few veggies to give it a little more flavor. 

Ingredients

30 lbs ripe tomatoes
1 Large green pepper – Cut in half and seeds/pulp removed
2 large stalks of celery – Cut in half
1 large onion – Peeled and left whole
5 cloves of garlic – peeled and left whole
A few stalks of parsley - left whole
Salt
Lemon Juice – 20 tablespoons

2010-06-15/Katg/d84d4e

2010-06-16/Katg/7c4061  2010-06-16/Katg/b884bf
Of course, start out with the freshest and ripest tomatoes available Wash them thoroughly and cut off any blemishes or excessive core parts. Cut them into quarters or eighths depending on the size of the tomato.  I use a Victorio strainer and at this point feeding the cut-up tomatoes into the hopper. This strainer separates the skin and seeds and just leaves the juice. Pour juice into a large stockpot and start to heat it, constantly adding while the juice is being extracted.

Alternate Method not using a Victorio Stainer

 Slice or quarter all of the tomatoes a couple lbs at a time and put into a large pot. Heat immediately to boiling while crushing. A potato masher works well. Continue to slowly add and crush freshly cut tomato quarters to the boiling mixture. Make sure the mixture boils constantly and vigorously while you add the remaining tomatoes. When the pot is full, heat this for another 5 minutes. (You may have to do this in batches).

Press the heated tomato juice through a sieve or food mill to remove skins and seeds. You can also use a juicer if it is one made for hot liquids. Keep adding the juice to a large Stockpot as it’s being extracted.

2010-06-16/Katg/1f4202

  2010-06-16/Katg/fd6e2c   2010-06-16/Katg/f9cd85
Bring the pot of juice to a boil and let this boil for about 10 minutes and skim off any large amounts of white foam. At this point the juice will be watery. Turn the pot down to a low boil and add the Green pepper, Celery, onion, garlic and parsley. Cook for about an hour and a half, occasionally stirring and until you see the consistency of tomato juice. Could take less time and could take more depending on the amount of water in your tomatoes. When your juice has cooked to the desired consistency it is time to add salt. Add it by constantly tasting and adding.

While the tomato juice is cooking – Prepare your jars. Wash your jars in soapy hot water and inspect the tops for any chips or cracks.

Fill a large canning pot with water and bring to a simmer. Keep it and full by adding in more water. – You want it to be at boiling point when you add the jars for processing.

As the tomato juice begins to thicken – start sterilizing your jars. I usually put about 3 inches of water into a large roastpan and bring it to a boil. Bring it down to a simmer and sit the jars upside down in the pan and let them sit in there for at least 10 minutes.. Add your lids also.
2010-06-16/Katg/f58cdc    2010-06-16/Katg/06d255   2010-06-16/Katg/e8a415
Add 2 tablespoons of lemon juice to the bottom of a quart jar (1 tablespoon to a pint). This will acidify the juice and helps avoid spoilage and increase safety.

Fill jars with hot tomato juice, leaving 1/4-inch headspace. Immediately put on a hot lid and hand tighten it with a band and set into the canner rack.

 

Ensure that the water in the Canner is boiling and lower the rack. There should be about 1-2 inches of water covering the top of the jars. Process the quart jars for 35 minutes (pint’s 30 minutes)

Be very carefull! Things are HOT!!!

Lift the jars out of the water with jar grips and let them cool on a towel, without touching or bumping in a draft-free place (usually takes overnight. Once the jars are cool, you can check that they are sealed verifying that the lid has been sucked down. Just press in the center, gently, with your finger. If it pops up and down (often making a popping sound), it is not sealed. If you put the jar in the refrigerator right away, you can still use it.
2010-06-16/Katg/e3f935 2010-06-16/Katg/7e918d
If your tomatoes need a little more ripening - spread them out and let them sit in the sun for a day. This is especially effective if you have a Tomato Watchdog on hand! lol There is no tinny taste to this tomato juice. Just fresh lovely goodness. This is also a great way of getting a recommended daily serving of fruits and vegetables.

C A N N I N G    E Q U I P M E N T

2010-06-16/Katg/2182b4  2010-06-16/Katg/f2e727       2010-06-16/Katg/51ccbd
A Victorio Strainer is a very nifty piece of equipment. Quite inexpensive and does all kinds of straining and milling. This strainer separates the skin and seeds out one end and spits the juice out the side! 
 

This basic Old fashioned type of canner comes with a rack and is big enough to hold 7 quart jars. 

These Jar Grips are indispensible when using them to remove jars from the boiling water bath. The little item on the left has a magnetic tip to retrieve jar tops that are sterilizing in boiling water.

Enjoy!

Visit my Cubit for an alternate recipe for Canned Whole Tomatoes

2010-06-16/Katg/6070ff

Related articles:
canning, preserving, tomato, tomato juice, victorio strainer

« More articles

Comments and discussion:
Subject Thread Starter Last Reply Replies
Beautiful! Weedwhacker Jun 27, 2010 12:41 AM 10
How to Pickle Peppers and green tomatoes mekos Jun 17, 2010 8:06 PM 11
An Afterthought Katg Jun 17, 2010 2:14 PM 3
excellent tutorial!! Gymgirl Jun 16, 2010 10:04 PM 1
I am impressed Boopaints Jun 16, 2010 9:21 PM 2

La Cucina di Kat

Aka: “Kat’s Kitchen”. A warm and friendly place to really talk about good food, tell stories and share recipes from days gone by. Good down to earth cooking with an ethnic flair!

» Home
» Forums
» Articles
» Pages
» Database

Cubit owner: Katg